Kombinasi Proses Filtrasi dan Ion Exchange Secara Kontinu pada Pembuatan Aquadm (Demineralized Water)

Reni Desmiarti

Abstract


Demineralized water is water free of dissolved mineral. Combination of filtration and ion exchanger processes were studied to treat demineralized water. The source of raw water is from Mountain Talang in District Solok. The study was conducted to investigate the effect of the amount of resin cartridge to electric conductivity (EC), pH and total dissolved solid (TDS).  The flow rate was set at 50 ml/menit. The results showed that the number of resin cartridge 4 (2 anion and cation 2), the removal efficiency of EC and TDS achieved at 89.09% and 90.91%, respectively. As for the number of cartridges 6 (3 anions and cations 3), the removal efficiency of EC and TDS obtained at 95.45% and 96.36%, respectively.  In addition, the effect of flow rate was also studied using cartridges resin 6 (3 anions and cations 3). Demineralized water has met the quality standard with a value of 0 ppm TDS, EC 0 μS / cm, pH 7.5. This studies shown that the combination of filtration and ion exchange filtration process can use effectively to treat demineralized water with high quality standard.

Full Text:

PDF

References


. Anonim. Water Quality Highly Purified Water.http://purewatergroup.com. Diakses 10 Mei 2015.

. Lee, C.C.,Lin, S.D., Handbook Of Environmental Engineering. McGraw-Hill Publishing, Tokyo (2005).

. Montgomery, J.M., Water Treatment Principles and Design. Johan Weley Inc. USA (2005).

. Berne F dan Cordornier J, “Industrial Water Treatmentâ€, Gulf Publishing Company Editions Technip. (1995).

. Muhaimin HM, dkk, Modifikasi Sistem Sirkulasi Air Pada Pembuat Air Suling Terdemineralisasi. Pusat Teknologi Nuklir Bahan dan Radiometri – BATAN, (2009).

. Malik, Abdul Maulana dan Ariyanto S. Widodo. Pengolahan Air Produk Reverse Osmosis Sebagai Umpan Boiler Dengan Menggunakan Ion exchange, Teknik Kimia Universitas Diponegoro; Semarang (2009).

. Utomo, Setyo, dkk, Analisis dan Pengendalian Konduktivitas Air Pada Kolom Resin Campuran (Mix-Bed) Sistem Air Bebas Mineral (GCA ). Buletin Pengelolaan Reaktor Nuklir,Vol. 9, No. 2 (2012).

. Budi Santoso, Leily Nurul Komariah, Hamdani, Zahroini Rahmah. Rancangan Sistem Pengolahan Air Umpan Boiler Pabrik Biodiesel Skala Pilot Universitas Sriwijaya. Proceedings Seminar Nasional Added Value of Energy Resources VII, Fakultas Teknik Universitas Sriwijaya (2015).

. Purwoto, Setyo dan Mario Monica, Demineralisasi Air Berbasis Resin Penukar Ion Terpadukan Dengan Membran Permeabel. Teknik Lingkungan Universitas Negeri Surabaya (2009).

. Mustahiqul, Laila Falah, dkk. Pembuatan Aquadm (Aquademineralized) Dari Air AC (Air Conditioner) Menggunakan Resin Kation Dan Anion. Jurusan Kimia Universitas Diponegoro Semarang (2009).




DOI: http://dx.doi.org/10.26555/chemica.v4i1.6730

Refbacks

  • There are currently no refbacks.



Abstracted/Indexed by:

 

 


 
CHEMICA: Jurnal Teknik Kimia
ISSN: 2355-875X (print) 2355-8776 (online)
Organized by Department of Chemical Engineering - Universitas Ahmad Dahlan
Published by Universitas Ahmad Dahlan
Website: http://journal.uad.ac.id/index.php/CHEMICA
Email 1: chemica@che.uad.ac.id
Email 2: agus.aktawan@che.uad.ac.id
 


View CHEMICA stat

Lisensi Creative Commons

This work is licensed under a Commons Attribution-ShareAlike 4.0 International License.