Kombinasi Proses Filtrasi dan Ion Exchange Secara Kontinu pada Pembuatan Aquadm (Demineralized Water)

Authors

  • Reni Desmiarti Universitas Bung Hatta

DOI:

https://doi.org/10.26555/chemica.v4i1.6730

Abstract

Demineralized water is water free of dissolved mineral. Combination of filtration and ion exchanger processes were studied to treat demineralized water. The source of raw water is from Mountain Talang in District Solok. The study was conducted to investigate the effect of the amount of resin cartridge to electric conductivity (EC), pH and total dissolved solid (TDS).  The flow rate was set at 50 ml/menit. The results showed that the number of resin cartridge 4 (2 anion and cation 2), the removal efficiency of EC and TDS achieved at 89.09% and 90.91%, respectively. As for the number of cartridges 6 (3 anions and cations 3), the removal efficiency of EC and TDS obtained at 95.45% and 96.36%, respectively.  In addition, the effect of flow rate was also studied using cartridges resin 6 (3 anions and cations 3). Demineralized water has met the quality standard with a value of 0 ppm TDS, EC 0 μS / cm, pH 7.5. This studies shown that the combination of filtration and ion exchange filtration process can use effectively to treat demineralized water with high quality standard.

Author Biography

Reni Desmiarti, Universitas Bung Hatta

Chemical Engineering Department

References

. Anonim. Water Quality Highly Purified Water.http://purewatergroup.com. Diakses 10 Mei 2015.

. Lee, C.C.,Lin, S.D., Handbook Of Environmental Engineering. McGraw-Hill Publishing, Tokyo (2005).

. Montgomery, J.M., Water Treatment Principles and Design. Johan Weley Inc. USA (2005).

. Berne F dan Cordornier J, “Industrial Water Treatmentâ€, Gulf Publishing Company Editions Technip. (1995).

. Muhaimin HM, dkk, Modifikasi Sistem Sirkulasi Air Pada Pembuat Air Suling Terdemineralisasi. Pusat Teknologi Nuklir Bahan dan Radiometri – BATAN, (2009).

. Malik, Abdul Maulana dan Ariyanto S. Widodo. Pengolahan Air Produk Reverse Osmosis Sebagai Umpan Boiler Dengan Menggunakan Ion exchange, Teknik Kimia Universitas Diponegoro; Semarang (2009).

. Utomo, Setyo, dkk, Analisis dan Pengendalian Konduktivitas Air Pada Kolom Resin Campuran (Mix-Bed) Sistem Air Bebas Mineral (GCA ). Buletin Pengelolaan Reaktor Nuklir,Vol. 9, No. 2 (2012).

. Budi Santoso, Leily Nurul Komariah, Hamdani, Zahroini Rahmah. Rancangan Sistem Pengolahan Air Umpan Boiler Pabrik Biodiesel Skala Pilot Universitas Sriwijaya. Proceedings Seminar Nasional Added Value of Energy Resources VII, Fakultas Teknik Universitas Sriwijaya (2015).

. Purwoto, Setyo dan Mario Monica, Demineralisasi Air Berbasis Resin Penukar Ion Terpadukan Dengan Membran Permeabel. Teknik Lingkungan Universitas Negeri Surabaya (2009).

. Mustahiqul, Laila Falah, dkk. Pembuatan Aquadm (Aquademineralized) Dari Air AC (Air Conditioner) Menggunakan Resin Kation Dan Anion. Jurusan Kimia Universitas Diponegoro Semarang (2009).

Downloads

Published

2017-07-01

Issue

Vol. 4 No. 1 (2017): Juni 2017

Section

Articles

License

Chemica: Jurnal Teknik Kimia allows readers to read, download, copy, distribute, print, search, or link to its articles' full texts and allows readers to use them for any other lawful purpose. The journal allows the author(s) to hold the copyright without restrictions. Finally, the journal allows the author(s) to retain publishing rights without restrictions

  • Authors are allowed to archive their submitted articles in an open access repository
  • Authors are allowed to archive the final published article in an open access repository with an acknowledgment of its initial publication in this journal

Creative Commons License
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 Generic License.

Â